Peugeot 305 Workshop Manuals and Repair Manuals
Every Manual available online - found by our community and shared for FREE. Enjoy!
Peugeot 305
The Peugeot 305 is a small family car produced by the French automaker Peugeot from 1977 to 1989. It was offered as a four-door saloon, five-door estate, and as a three-door van body derivative. It was initially available with a choice of two petrol engines: a 1,290 cc, 65 PS (48 kW; 64 hp) unit for the GL and GR models or a 1,472 cc, 74 PS (54 kW; 73 hp) for the top-specification SR model. Power came from 1.3 or 1.5 petrol and 1.55 litre diesel engines and later, after the facelift, the 1.5 was replaced by a 1.6 and a Peugeot 1.9 petrol and XUD diesel engine were added. Production of saloons ceased in 1988 following the launch of the slightly larger and more powerful Peugeot 405.Peugeot 305 FAQ's
How do I bleed the cooling system in a Peugeot 305?
To bleed the cooling system in your Peugeot 305, ensure the engine is completely cool. Locate the bleed screw on the top of the radiator or near the thermostat housing. Slowly loosen the screw while the engine is running and allow any trapped air to escape. Once a steady stream of coolant without air bubbles is observed, tighten the bleed screw and check the coolant level.
How do I change the brake pads in a Peugeot 305?
To change the brake pads in your Peugeot 305, start by loosening the lug nuts on the wheel where you'll be replacing the pads. Then, elevate the vehicle using a jack and secure it with jack stands. Remove the wheel to access the brake caliper. Remove the caliper bolts, slide out the old brake pads, and replace them with new ones. Finally, reassemble the caliper, mount the wheel, and tighten the lug nuts.
How do I change the oil in a Peugeot 305?
To change the oil in your Peugeot 305, start by locating the oil drain plug underneath the engine and remove it using a wrench. Allow the old oil to fully drain out before replacing the drain plug. Then, locate and remove the oil filter, making sure to replace it with a new one before adding fresh oil to the engine.
How do I check and top up the coolant level in a Peugeot 305?
To check and top up the coolant level in your Peugeot 305, first make sure the engine is completely cool. Locate the coolant reservoir, usually a translucent plastic tank with level markings. Open the reservoir cap and visually inspect the coolant level, ensuring it reaches the "Full" or "Max" mark. If necessary, add a mixture of coolant and distilled water to the reservoir until it reaches the desired level.
How do I check the brake fluid level in a Peugeot 305?
To check the brake fluid level in your Peugeot 305, locate the brake fluid reservoir under the hood, usually near the back of the engine compartment. The reservoir is typically translucent, allowing you to see the fluid level. Ensure the vehicle is on level ground and carefully remove the reservoir cap. The fluid should be at or slightly above the "Min" or "Full" mark. If necessary, add the recommended brake fluid to bring it to the correct level.
How do I replace a battery in a Peugeot 305?
To replace the battery in your Peugeot 305, start by removing the negative (-) terminal followed by the positive (+) terminal. Then, remove the battery hold-down clamp or bracket to free the battery from its position. Install the new battery by reversing the above steps, ensuring proper connection and tightening the terminals securely.
How do I replace a fuel filter in a Peugeot 305?
To replace a fuel filter in your Peugeot 305, locate the filter usually along the fuel line, near the fuel tank or engine compartment. Ensure the engine is cool and relieve fuel pressure by disconnecting the fuel pump fuse or relay and starting the engine until it stalls. Use a wrench or pliers to disconnect the fuel lines from the old filter and remove it. Install the new filter, ensuring proper alignment, and reconnect the fuel lines.
How do I replace a headlight bulb in a Peugeot 305?
To replace a headlight bulb in your Peugeot 305, open the hood and locate the back of the headlight assembly. Remove the electrical connector from the bulb by pressing the release tab and pulling it off. Then, twist the bulb counterclockwise to remove it from the socket and replace it with a new bulb. Finally, reconnect the electrical connector and test the headlight before closing the hood.
How do I replace a serpentine belt in a Peugeot 305?
To replace a serpentine belt in your Peugeot 305, locate the belt routing diagram usually found on the engine compartment or in the owner's manual. Use a wrench or tensioner tool to relieve tension on the belt, then slip it off the pulleys. Install the new belt following the belt routing diagram, ensuring it sits properly on each pulley. Finally, release the tensioner to apply tension to the new belt.
How do I replace a spark plug in a Peugeot 305?
To replace a spark plug in your Peugeot 305, locate the spark plug wires or ignition coils on top of the engine. Disconnect the wire or coil from the spark plug, then use a spark plug socket and ratchet to remove the old spark plug. Install the new spark plug, ensuring proper tightening torque, and reconnect the wire or coil. Repeat the process for each spark plug.
How do I replace a thermostat in a Peugeot 305?
To replace a thermostat in your Peugeot 305, locate the thermostat housing usually attached to the engine block or cylinder head. Drain the coolant from the radiator until it is below the level of the thermostat housing. Remove the housing and old thermostat, ensuring you note the orientation of the thermostat. Install the new thermostat, ensuring proper alignment, and reassemble the housing. Refill the cooling system with fresh coolant and check for any leaks.
How do I reset the service indicator in a Peugeot 305?
To reset the service indicator in your Peugeot 305, turn the ignition key to the "on" position without starting the engine. Press and hold the trip reset button on the instrument cluster until the service indicator starts to flash. Release the button, then press and hold it again until the indicator resets and turns off.
How do I troubleshoot an electrical issue in a Peugeot 305?
When troubleshooting an electrical issue in your Peugeot 305, start by checking the fuse box for any blown fuses and replace them if necessary. Inspect the battery terminals for corrosion or loose connections and clean/tighten them if needed. If the issue persists, consult the vehicle's repair manual for specific electrical system diagrams and test the relevant components using a multimeter or appropriate diagnostic tools.
How often should I replace the air filter in a Peugeot 305?
It is recommended to replace the air filter in your Peugeot 305 every 12,000 to 15,000 miles or as specified in the manufacturer's guidelines. However, if you frequently drive in dusty or off-road conditions, it may be necessary to replace the air filter more frequently to ensure optimal engine performance and fuel efficiency.
What is the recommended tire pressure for a Peugeot 305?
The recommended tire pressure for a Peugeot 305 is typically listed on a sticker located on the driver's side door jamb or in the owner's manual. It is important to check and maintain the correct tire pressure regularly to ensure optimal handling, tire wear, and fuel efficiency.
Get notified for new manuals?
We'll send you a quick email when a new Peugeot 305 manual is added.
There are currently no manuals available for Peugeot 305 at this time.