Jaguar X Type 2004 Misc Document Air Blend Loose PDF

Date of issue 04/04 Bulletin Number XT412-02 Page 1 of 6
DATE
XT412-0204/04
SERSER
SERSER
SER
VICEVICE
VICEVICE
VICE
TECHNICAL BULLETINTECHNICAL BULLETIN
TECHNICAL BULLETINTECHNICAL BULLETIN
TECHNICAL BULLETIN
Vehicle Fogging/Climate Control Slow To Cool
Vehicle – Air Blend Door Loose –
Repair Procedure
2002-04 MY
X-TYPE
C00001-D99632
MODEL
VIN
X-TYPE
NOTE: THE INFORMANOTE: THE INFORMA
NOTE: THE INFORMANOTE: THE INFORMA
NOTE: THE INFORMA
TION IN TECHNICALTION IN TECHNICAL
TION IN TECHNICALTION IN TECHNICAL
TION IN TECHNICAL
BULLETINS IS INTENDED FOR USE BY BULLETINS IS INTENDED FOR USE BY
BULLETINS IS INTENDED FOR USE BY BULLETINS IS INTENDED FOR USE BY
BULLETINS IS INTENDED FOR USE BY
TRAINED, PROFESSIONAL TRAINED, PROFESSIONAL
TRAINED, PROFESSIONAL TRAINED, PROFESSIONAL
TRAINED, PROFESSIONAL
TECHNI- TECHNI-
TECHNI- TECHNI-
TECHNI-
CIANS WITH THE KNOWLEDGE, TCIANS WITH THE KNOWLEDGE, T
CIANS WITH THE KNOWLEDGE, TCIANS WITH THE KNOWLEDGE, T
CIANS WITH THE KNOWLEDGE, T
OOLS, OOLS,
OOLS, OOLS,
OOLS,
AND EQUIPMENT TAND EQUIPMENT T
AND EQUIPMENT TAND EQUIPMENT T
AND EQUIPMENT T
O DO THE JOB PROPERLO DO THE JOB PROPERL
O DO THE JOB PROPERLO DO THE JOB PROPERL
O DO THE JOB PROPERL
YY
YY
Y
AND SAFELAND SAFEL
AND SAFELAND SAFEL
AND SAFEL
YY
YY
Y
. IT INFORMS. IT INFORMS
. IT INFORMS. IT INFORMS
. IT INFORMS
THESE TECHNICIANS OF CONDITIONS THATHESE TECHNICIANS OF CONDITIONS THA
THESE TECHNICIANS OF CONDITIONS THATHESE TECHNICIANS OF CONDITIONS THA
THESE TECHNICIANS OF CONDITIONS THA
T MAT MA
T MAT MA
T MA
YY
YY
Y
OCCUR ON SOME VEHICLES, OR PROVIDES INFORMA OCCUR ON SOME VEHICLES, OR PROVIDES INFORMA
OCCUR ON SOME VEHICLES, OR PROVIDES INFORMA OCCUR ON SOME VEHICLES, OR PROVIDES INFORMA
OCCUR ON SOME VEHICLES, OR PROVIDES INFORMA
TION THATION THA
TION THATION THA
TION THA
TT
TT
T
COULD COULD
COULD COULD
COULD
ASSIST IN PROPER VEHICLE SERASSIST IN PROPER VEHICLE SER
ASSIST IN PROPER VEHICLE SERASSIST IN PROPER VEHICLE SER
ASSIST IN PROPER VEHICLE SER
VICE. THE PROCEDURES SHOULD NOT BE PERFORMED BYVICE. THE PROCEDURES SHOULD NOT BE PERFORMED BY
VICE. THE PROCEDURES SHOULD NOT BE PERFORMED BYVICE. THE PROCEDURES SHOULD NOT BE PERFORMED BY
VICE. THE PROCEDURES SHOULD NOT BE PERFORMED BY
“DO-IT “DO-IT
“DO-IT “DO-IT
“DO-IT
--
--
-
YOURSELFERS.” DO NOT YOURSELFERS.” DO NOT
YOURSELFERS.” DO NOT YOURSELFERS.” DO NOT
YOURSELFERS.” DO NOT
ASSUME THAASSUME THA
ASSUME THAASSUME THA
ASSUME THA
T T
T T
T
AA
AA
A
CONDITION DESCRIBED CONDITION DESCRIBED
CONDITION DESCRIBED CONDITION DESCRIBED
CONDITION DESCRIBED
AFFECTS AFFECTS
AFFECTS AFFECTS
AFFECTS
YOUR CAR. CONTYOUR CAR. CONT
YOUR CAR. CONTYOUR CAR. CONT
YOUR CAR. CONT
ACT ACT
ACT ACT
ACT
AA
AA
A
JAGUAR JAGUAR
JAGUAR JAGUAR
JAGUAR
RETRET
RETRET
RET
AILER TAILER T
AILER TAILER T
AILER T
O DETERMINE WHETHER THE BULLETIN O DETERMINE WHETHER THE BULLETIN
O DETERMINE WHETHER THE BULLETIN O DETERMINE WHETHER THE BULLETIN
O DETERMINE WHETHER THE BULLETIN
APPLIES TAPPLIES T
APPLIES TAPPLIES T
APPLIES T
O O
O O
O
YOUR VEHICLE.YOUR VEHICLE.
YOUR VEHICLE.YOUR VEHICLE.
YOUR VEHICLE.
Issue:Issue:
Issue:Issue:
Issue:
On some 2002-04 MY X-TYPE vehicles within the above VIN range, customers may
have concerns with the vehicle interior fogging or the climate control cooling the vehicle
slowly.
The concern may be caused by the air inlet blend door being loose on the actuator
shaft.
Action:Action:
Action:Action:
Action:
In case of a customer complaint of the above condition on a 2002-04 MY X-TYPE
vehicle within the above VIN range, first test the operation of the air inlet blend door.
Set the fan speed to MAX and manually de-select the recirc button, there should be an
audible difference in the climate control temperature motor noise. If the volume stays
the same then the air inlet blend door is suspect.
To rectify follow the workshop procedure outlined below.
WORKSHOP PROCEDURE
1. Open door.
2. Turn ignition ‘ON’.
3. Operate front seat fully rearward for access.
4. The air recirculation switch should be in the fresh air mode.
5. Turn ignition ‘OFF’.