Jaguar XK 2005 Misc. Document Door Trim Panel Loose PDF

Date of issue 09/05 Bulletin Number 501-57 Page 1 of 3
DATE
501-5709/05
SERVICE
TECHNICAL BULLETIN
Door Trim Panel Loose or Adrift –
Upper Rear Retainer Clip Bracket –
Repair
2000 MY-ON
XK Range
A00016-ON
MODEL
VIN
XK
NOTE: THE INFORMATION IN TECHNICAL BULLETINS IS INTENDED FOR USE BY TRAINED, PROFESSIONAL TECHNI-
CIANS WITH THE KNOWLEDGE, TOOLS, AND EQUIPMENT TO DO THE JOB PROPERLY AND SAFELY. IT INFORMS
THESE TECHNICIANS OF CONDITIONS THAT MAY OCCUR ON SOME VEHICLES, OR PROVIDES INFORMATION THAT
COULD ASSIST IN PROPER VEHICLE SERVICE. THE PROCEDURES SHOULD NOT BE PERFORMED BY “DO-IT-
YOURSELFERS.” DO NOT ASSUME THAT A CONDITION DESCRIBED AFFECTS YOUR CAR. CONTACT A JAGUAR
DEALER TO DETERMINE WHETHER THE BULLETIN APPLIES TO YOUR VEHICLE.
Issue:
Some vehicles may exhibit a door trim panel that is loose due to a broken upper rear
retainer clip bracket. The bracket can be renewed, to avoid replacing the complete trim
panel.
Action:
In case of a verified customer complaint of the above condition, do not replace the door
trim panel. Install a new retainer clip bracket on the door trim panel as outlined below.
1. Remove the door trim panel (see Global Technical Reference GTR Workshop
Manual, section: 501-05).
2. Using a suitable pen, draw a line around the damaged retainer clip bracket
(Illustration 1).
E63414
ILLUSTRATION 1
MARK LOCATION OF RETAINER

Jaguar XK 2005 Misc. Document Door Trim Panel Loose Summary of Content

Date of issue 09/05 Bulletin Number 501-57 Page 1 of 3DATE501-5709/05SERVICETECHNICAL BULLETINDoor Trim Panel Loose or Adrift Upper Rear Retainer Clip Bracket Repair2000 MY-ONXK RangeA00016-ONMODELVINXKNOTE: THE INFORMATION IN TECHNICAL BULLETINS IS INTENDED FOR USE BY TRAINED, PROFESSIONAL TECHNI-CIANS WITH THE KNOWLEDGE, TOOLS, AND EQUIPMENT TO DO THE JOB PROPERLY AND SAFELY. IT INFORMSTHESE TECHNICIANS OF CONDITIONS THAT MAY OCCUR ON SOME VEHICLES, OR PROVIDES INFORMATION THATCOULD ASSIST IN PROPER VEHICLE SERVICE. THE PROCEDURES SHOULD NOT BE PERFORMED BY DO-IT-YOURSELFERS. DO NOT ASSUME THAT A CONDITION DESCRIBED AFFECTS YOUR CAR. CONTACT A JAGUARDEALER TO DETERMINE WHETHER THE BULLETIN APPLIES TO YOUR VEHICLE.Issue:Some vehicles may exhibit a door trim panel that is loose due to a broken upper rearretainer clip bracket. The bracket can be renewed, to avoid replacing the complete trimpanel.Action:In case of a verified customer complaint of the above condition, do not replace the doortrim panel. Install a new retainer clip bracket on the door trim panel as outlined below.1. Remove the door trim panel (see Global Technical Reference GTR WorkshopManual, section: 501-05).2. Using a suitable pen, draw a line around the damaged retainer clip bracket(Illustration 1).E63414ILLUSTRATION 1MARK LOCATION OF RETAINER