Mitsubishi Lancer Evolution 2006 MITSUBISHI LANCER EVOLUTION 9 SERVICE MANUAL PDF

GROUP INDEX
00
General . . . . . . . . . . . . . . . . . . . . . . .
11
Engine . . . . . . . . . . . . . . . . . . . . . . . .
12
Engine Lubrication . . . . . . . . . . . . . .
13
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . .
14
Engine Cooling . . . . . . . . . . . . . . . . .
15
Intake and Exhaust . . . . . . . . . . . . . .
16
Engine Electrical. . . . . . . . . . . . . . . .
17
Engine and Emission Control . . . . .
21
Clutch. . . . . . . . . . . . . . . . . . . . . . . . .
22
Manual Transaxle . . . . . . . . . . . . . . .
25
Propeller Shaft . . . . . . . . . . . . . . . . .
26
Front Axle . . . . . . . . . . . . . . . . . . . . .
27
Rear Axle . . . . . . . . . . . . . . . . . . . . . .
31
Wheel and Tire . . . . . . . . . . . . . . . . .
32
Power Plant Mount . . . . . . . . . . . . . .
33
Front Suspension . . . . . . . . . . . . . . .
34
Rear Suspension . . . . . . . . . . . . . . .
NOTE:
For the information on all service manual
groups not listed above, please refer to
Volume 2, 3 and 4.
Alphabetical Index . . . . . . . . . . . . . .
2006
MITSUBISHI
LANCER
EVOLUTION
SERVICE MANUAL
Volume 1
FOREWORD
This service manual is subdivided into various group
categories. Each section contains diagnostic,
disassembly, repair, and installation procedures,
along with complete specifications and tightening
references. Use of this manual will aid in properly
performing any service necessary to maintain or
restore the high levels of performance and reliability
designed into this Mitsubishi vehicle.
This manual is designed for use with the 2006
LANCER EVOLUTION Service Manual Volume 2, and
the 2003 LANCER EVOLUTION Body Repair Manual
to provide complete service information for the 2006
LANCER EVOLUTION.
When reference is made in this manual to a brand
name, number, or specific tool, an equivalent product
may be used in place of the recommended item. All
information, illustrations and specifications contained
in this manual are based on the latest product
information available at the time of publication
approval. The right is reserved to make changes at
any time without notice.
No part of this publication may be reproduced, stored in any retrieval
system of transmitted, in any form or by any means, including but not
limited to electronic, mechanical photocopying, recording or otherwise,
without the prior written permission of Mitsubishi Motors Corporation.
©2005 Mitsubishi Motors Corporation
All Rights Reserved
Printed in USA
MSSP-206B-2006 (1/2)
NOTE:
For the information on all service manual
groups not listed above, please refer to Volume
2.

Mitsubishi Lancer Evolution 2006 MITSUBISHI LANCER EVOLUTION 9 SERVICE MANUAL Summary of Content

GROUP INDEX00General . . . . . . . . . . . . . . . . . . . . . . . 11Engine . . . . . . . . . . . . . . . . . . . . . . . . 12Engine Lubrication . . . . . . . . . . . . . . 13Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 14Engine Cooling . . . . . . . . . . . . . . . . . 15Intake and Exhaust . . . . . . . . . . . . . . 16Engine Electrical. . . . . . . . . . . . . . . . 17Engine and Emission Control . . . . . 21Clutch. . . . . . . . . . . . . . . . . . . . . . . . . 22Manual Transaxle . . . . . . . . . . . . . . . 25Propeller Shaft . . . . . . . . . . . . . . . . . 26Front Axle . . . . . . . . . . . . . . . . . . . . . 27Rear Axle . . . . . . . . . . . . . . . . . . . . . . 31Wheel and Tire . . . . . . . . . . . . . . . . . 32Power Plant Mount . . . . . . . . . . . . . . 33Front Suspension . . . . . . . . . . . . . . . 34Rear Suspension . . . . . . . . . . . . . . . NOTE:For the information on all service manualgroups not listed above, please refer toVolume 2, 3 and 4.Alphabetical Index . . . . . . . . . . . . . . 2006MITSUBISHI LANCER EVOLUTIONSERVICE MANUALVolume 1FOREWORDThis service manual is subdivided into various groupcategories. Each section contains diagnostic,disassembly, repair, and installation procedures,along with complete specifications and tighteningreferences. Use of this manual will aid in properlyperforming any service necessary to maintain orrestore the high levels of performance and reliabilitydesigned into this Mitsubishi vehicle.This manual is designed for use with the 2006LANCER EVOLUTION Service Manual Volume 2, andthe 2003 LANCER EVOLUTION Body Repair Manualto provide complete service information for the 2006LANCER EVOLUTION.When reference is made in this manual to a brandname, number, or specific tool, an equivalent productmay be used in place of the recommended item. Allinformation, illustrations and specifications containedin this manual are based on the latest productinformation available at the time of publicationapproval. The right is reserved to make changes atany time without notice.No part of this publication may be reproduced, stored in any retrievalsystem of transmitted, in any form or by any means, including but notlimited to electronic, mechanical photocopying, recording or otherwise,without the prior written permission of Mitsubishi Motors Corporation.2005 Mitsubishi Motors CorporationAll Rights ReservedPrinted in USAMSSP-206B-2006 (1/2)NOTE:For the information on all service manualgroups not listed above, please refer to Volume2.