Nissan 350Z Workshop Maunual 2004 (26) PDF

LT-1
LIGHTING SYSTEM
K ELECTRICAL
CONTENTS
C
D
E
F
G
H
I
J
L
M
SECTION LT
A
B
LT
Revision: 2004 December 2004.5 350Z
LIGHTING SYSTEM
PRECAUTIONS .......................................................... 5
Precautions for Supplemental Restraint System
(SRS) ?AIR BAG? and ?SEAT BELT PRE-TEN-
SIONER? .................................................................. 5
Precautions for Battery Service ................................ 5
General Precautions for Service Operations ............ 6
Wiring Diagrams and Trouble Diagnosis .................. 6
HEADLAMP (FOR USA) - XENON TYPE - ................ 7
Component Parts and Harness Connector Location ..... 7
System Description .................................................. 7
OUTLINE ............................................................... 7
COMBINATION SWITCH READING FUNCTION ..... 9
EXTERIOR LAMP BATTERY SAVER CONTROL ..... 9
VEHICLE SECURITY SYSTEM ............................ 9
XENON HEADLAMP ............................................. 9
CAN Communication System Description ................ 9
CAN Communication Unit ........................................ 9
Schematic .............................................................. 10
Wiring Diagram ? H/LAMP ? ................................11
Terminals and Reference Values for BCM ............. 15
Terminals and Reference Values for IPDM E/R ..... 16
How to Proceed With Trouble Diagnosis ................ 16
Preliminary Check .................................................. 17
CHECK POWER SUPPLY AND GROUND CIR-
CUIT .................................................................... 17
CONSULT-II Functions (BCM) ............................... 18
CONSULT-II BASIC OPERATION ....................... 18
WORK SUPPORT ............................................... 19
DATA MONITOR ................................................. 19
ACTIVE TEST ..................................................... 20
CONSULT-II Functions (IPDM E/R) ....................... 20
CONSULT-II BASIC OPERATION ....................... 21
DATA MONITOR ................................................. 22
ACTIVE TEST ..................................................... 22
SELF-DIAGNOSTIC RESULTS .......................... 22
Headlamp High Beam Does Not Illuminate (Both
Sides) ..................................................................... 23
Headlamp High Beam Does Not Illuminate (One
Side) ....................................................................... 25
High Beam Indicator Lamp Does Not Illuminate .... 26
Headlamp Low Beam Does Not Illuminate (Both
Sides) .....................................................................26
Headlamp Low Beam Does Not Illuminate (One
Side) .......................................................................29
Headlamps Does Not Turn OFF .............................31
CAUTION: ..............................................................32
Xenon Headlamp Trouble Diagnosis ......................32
Aiming Adjustment ..................................................33
PREPARATION BEFORE ADJUSTING ..............33
LOW BEAM AND HIGH BEAM ...........................33
ADJUSTMENT USING AN ADJUSTMENT
SCREEN (LIGHT/DARK BORDERLINE) ............34
Bulb Replacement .................................................. 34
HEADLAMP (UPPER) LOW BEAM .....................34
HEADLAMP (LOWER) HIGH BEAM ...................35
PARKING LAMP (CLEARANCE LAMP) ..............35
FRONT TURN SIGNAL LAMP ............................35
FRONT SIDE MARKER LAMP ...........................35
Removal and Installation ........................................36
REMOVAL ...........................................................36
INSTALLATION ...................................................36
Disassembly and Assembly ....................................36
DISASSEMBLY ...................................................37
ASSEMBLY .........................................................37
Servicing to Replace Headlamps When Damaged ...37
INSTALLATION OF HEADLAMP BRACKET .......37
HEADLAMP (FOR USA) - CONVENTIONAL TYPE - ...38
Component Parts and Harness Connector Location ...38
System Description ................................................. 38
OUTLINE .............................................................38
COMBINATION SWITCH READING FUNCTION ...39
EXTERIOR LAMP BATTERY SAVER CONTROL ...40
VEHICLE SECURITY SYSTEM .......................... 40
CAN Communication System Description ..............40
CAN Communication Unit .......................................40
Schematic ...............................................................41
Wiring Diagram ? H/LAMP ? ...............................42
Terminals and Reference Values for BCM ..............46
Terminals and Reference Values for IPDM E/R ......47
How to Proceed With Trouble Diagnosis ................48